Rossmax Neb Tester Bruksanvisning

Rossmax Medicinsk Neb Tester

Läs nedan 📖 manual på svenska för Rossmax Neb Tester (2 sidor) i kategorin Medicinsk. Denna guide var användbar för 4 personer och betygsatt med 4.5 stjärnor i genomsnitt av 2 användare

Ladda ner PDF

Sida 1/2

Instruction Manual

Model: Neb Tester

Portable Testing Device

for Nebulizer

www.rossmax.com

OBM_IB_NebTester_

EN_SW_ver2118

Manufacturer: Rossmax International Ltd.,

12F., No. 189, Kang Chien Rd., Taipei, 114, Taiwan

www.rossmax.com

Specications

Cautions and maintenance

1. This device should be used with nebulizer only.

2. Place the device and nebulizer on a at, horizontal surface while in use.

3. The device must be in a vertical position while in use.

4. Turn the regulator slowly to avoid possible damage.

5. Do not completely unscrew regulator stem.

6. Do not attempt to disassemble the device.

7. Avoid excessive vibration, physical impact and dropping.

8. Do not store the device in direct sunlight, high temperature or humidity.

9. Keep the device away from static electricity.

10. For the rst use, open the rubber vent-plug on the back side of pressure gauge and

then close it in order to balance the pressure after the transportation.

Note: Do not open the rubber vent-plug when the device is in a vertical position to avoid

leakages of oil material from the pressure gauge.

Power source No need

Operating temperature 0 ~ 54ºC

Storage temperature - 10 ~ 60ºC

Air ow scale 1 ~ 10 L/min

accuracy ± 4% of full scale

Pressure scale 0 ~ 60 PSI

accuracy ± 2% of full scale

Weight 1000 g

Dimension 128 (L)*120(W)*158 (H) mm

Rossmax Neb Tester is a portable and easy-to-use device that allows the user to quickly

check the performance of the pump of a compressor nebulizer. Power source is not

required for Neb Tester during operation and the test result is easy to read and interpret.

Neb Tester consists of an oil pressure gauge, ow meter, air tube and stainless steel stand.

This device is used to simulate the working conditions of the pump when the nebulizer is

in operation with a medication cup, and you are able to check:

1. Maximum (free) air ow

2. Operational air ow at a particular pressure

3. Maximum air pressure

Parts name/location

Introduction

psi

kg/cm2

20 30

psi

kg/cm2

20 30

Flow meter

Regulator

Pressure

gauge

Air tube

Insert air tube into connectorPlace the device in a

horizontal position

Open the rubber vent-plug

and then close it after

Back view

Installation

Operation procedures

psi

kg/cm2

20 30

psi

kg/cm2

20 30

1. Check maximum (free) air ow

Step 1: Turn the regulator of ow meter anticlockwise around 2~3 circles.

Step 2: Insert the other end of air tube into the air outlet of the nebulizer.

Step 3: Power on the nebulizer.

Step 4: Keep the nebulizer running for 30 seconds to warm up.

Step 5: Adjust air ow and set the level of the pressure at 0 PSI by turning the

regulator of ow meter.

Step 6: Check the air ow rate.

Step 7: Turn off the nebulizer.

Step 8: Disconnect the air tube from the nebulizer.

2. Check operational air ow at a particular pressure

Step 1: Turn the regulator of ow meter anticlockwise around 2~3 circles.

Step 2: Insert the other end of air tube into the air outlet of the nebulizer.

Step 3: Power on the nebulizer.

Step 4: Keep the nebulizer running for 30 seconds to warm up.

Step 5: Set the pressure to a desired level by adjusting the regulator of the ow

meter.

Step 6: Check the air ow rate.

Pressure (PSI) Flow rate (L/min)

NA100 / NB500 (N1) 15.0 ≥ 3.5

NE100 / NF100/ NJ100 (N4) 15.0 ≥ 3.5

NK1000/ NB80 / NF80 (N1) 8.0 ≥ 3.0

NB60 / NI60/ NH60 / NF60 (N1) 8.0 ≥ 2.0

NL100 (N2) 10.5 ≥ 3.5

Step 7: Turn off the nebulizer.

Step 8: Disconnect the air tube from the nebulizer.

3. Check maximum air pressure

Step 1: Turn the regulator of ow meter anticlockwise around 2~3 circles.

Step 2: Insert the other end of air tube into the air outlet of the nebulizer.

Step 3: Power on the nebulizer.

Step 4: Keep the nebulizer running for 30 seconds to warm up.

Step 5: Set the air ow rate at 0 L/min by turning the regulator of ow meter

clockwise completely.

Step 6: Check the values on the pressure gauge.

Step 7: Turn off the nebulizer.

Step 8: Disconnect the air tube from the nebulizer.

Air

compressor

connector

Rubber

vent-plug

Produktspecifikationer

Varumärke:	Rossmax
Kategori:	Medicinsk
Modell:	Neb Tester
Vikt:	34650 g
Bredd:	1138 mm
Djup:	700 mm
Höjd:	2315 mm
Antal hyllor:	1 schappen
Maximal viktkapacitet:	100 kg
Ramfärg:	Zilver
VESA montering:	Ja
Panelmonteringsgränssnitt:	200 x 200,300 x 300,400 x 200,400 x 400,400 x 600,800 x 400,800 x 600,1000 x 600 mm
Tiltvinkelområde:	-10 - 5 °
Maximal skärmstorlek:	100 "
Hjulhjul:	Ja
Garantiperiod:	1 jaar
lutningsjusteringar:	Ja
Lastad:	Nee
Hyllor:	Ja
Färg topp:	Zilver
Färg planka:	Zwart