POLARIS PB4-60 Bruksanvisning
Läs nedan 📖 manual på svenska för POLARIS PB4-60 (40 sidor) i kategorin Pomp. Denna guide var användbar för 3 personer och betygsatt med 4.5 stjärnor i genomsnitt av 2 användare
Sida 1/40
FOR YOUR SAFETY - This product must be installed and serviced by a contractor who is licensed and qualied
in pool equipment by the jurisdiction in which the product will be installed, where such state or local requirements
exist. In the event no such state or local requirement exists, the maintainer must be a professional with sufcient
experience in pool equipment installation and maintenance, so that all of the instructions in this manual can be
followed exactly. Improper installation and/or operation can create dangerous electrical hazards, which can cause
high voltages to run through the electrical system. Before installing this product, read and follow all warning
notices and instructions that accompany this product. Failure to follow warning notices and instructions may result
in property damage, personal injury, or death. Improper installation and/or operation will void the warranty.
If these instructions are not followed exactly, a re or explosion may result, causing property damage, personal
injury, or death.
ATTENTION INSTALLER: This manual contains important information about the installation,
operation and safe use of this product. This information should be given to the owner/operator of
this equipment.
WARNING
H0344400 REVD
Pressure Cleaner
Booster Pump
Installation and
Operation Manual
For Polaris PB4-60 Booster Pumps with Serial Numbers beginning with "PB"
and a manufacturing date on or after Dec 1, 2011.
ENGLISH | FRANÇAIS
Page 2 ENGLISH Polaris® PB4-60 Booster Pump | Installation and Operation Manual
Table of Contents
Section 1. IMPORTANT SAFETY INSTRUC-
TIONS 3 .............................................
1.1 Safety Instructions ............................................ 3
1.2 Pool Pump Suction Entrapment
Prevention Guidelines ....................................... 5
Section 2. General Description 6 ......................
2.1 Introduction ....................................................... 6
2.2 Description ........................................................ 6
2.3 Preparation ....................................................... 6
Section 3. Installation 6 .....................................
3.1 Electrical Installation ......................................... 6
3.1.1 Voltage Checks 6 .....................................
3.1.2 Bonding and Grounding 6 .........................
3.2 Electrical ........................................................... 6
3.2.1 Electrical Wiring 7 .....................................
3.3 Plumbing ........................................................... 7
3.3.1 Requirements ........................................ 7
3.3.2 Pipe Sizing 8 .............................................
3.3.3 Pump Location 8 .......................................
3.3.4 Install the Pump 9 .....................................
3.3.5 Installation Recommendations 9 ..............
3.3.6 Check the Water Flow 9 ...........................
3.3.7 Conduct Pressure Test .......................... 10
Section 4. Operation 10 .......................................
4.1 Start-up ............................................................. 10
Section 5. Maintenance .................................. 11
5.1 Winterizing the Pump ........................................ 11
Section 6. Troubleshooting and Repair 12 ........
6.1 Troubleshooting ................................................ 12
6.2 Service Technician Maintenance ...................... 13
6.2.1 Blocked Impeller 13 ....................................
6.2.2 Impeller Removal 13 ...................................
6.2.3 Impeller Replacement 14 ............................
6.2.4 Mechanical Seal Replacement 14 ..............
6.2.5 Motor Replacement 15 ..............................
Section 7. Product Specications and Techni-
cal Data 16 ..........................................
7.1 Replacement Parts List ..................................... 16
7.2 Polaris PB4-60 Booster Pump Exploded View . 16
7.3 Pump Dimensions ............................................. 17
7.4 Visual Identication of the New Polaris PB4-60
Booster Pump ................................................... 18
DATE OF INSTALLATION
INSTALLER INFORMATION
INITIAL PRESSURE GAUGE READING (WITH CLEAN FILTER)
PUMP MODEL HORSEPOWER
NOTES:
EQUIPMENT INFORMATION RECORD
Page 3
ENGLISH
Polaris® PB4-60 Booster Pump | Installation and Operation Manual
Section 1. IMPORTANT SAFETY INSTRUCTIONS
READ AND FOLLOW ALL INSTRUCTIONS
1.1 Safety Instructions
All electrical work must be performed by a licensed electrician and conform to all national, state, and local codes.
When installing and using this electrical equipment, basic safety precautions should always be followed, including the
following:
To reduce the risk of injury, do not permit children to use this product.
WARNING
To reduce the risk of property damage or injury, do not attempt to change the backwash (multiport, slide, or full
ow) valve position with the pump running.
WARNING
Zodiac® pumps are powered by a high voltage electric motor and must be installed by a licensed or certied
electrician or a qualied swimming pool service technician.
WARNING
RISK OF ELECTRIC SHOCK, FIRE, PERSONAL INJURY, OR DEATH. Connect only to a branch circuit that is
protected by a ground-fault circuit-interrupter (GFCI). Contact a qualied electrician if you cannot verify that the
circuit is protected by a GFCI. Make sure such a GFCI should be provided by the installer and should be tested on
a routine basis. To test the GFCI, push the test button. The GFCI should interrupt power. Push the reset button.
Power should be restored. If the GFCI fails to operate in this manner, the GFCI is defective. If the GFCI interrupts
power to the pump without the test button being pushed, a ground current is owing, indicating the possibility
of electrical shock. Do not use the pump. Disconnect the pump and have the problem corrected by a qualied
service representative before using.
Due to the potential risk of re, electric shock, or injuries to persons, Zodiac Pumps must be installed in
accordance with the National Electrical Code® (NEC®), all local electrical and safety codes, and the Occupational
Safety and Health Act (OSHA®). Copies of the NEC may be ordered from the National Fire Protection Association ®
(NFPA®) online at www.nfpa.org or call 617-770-3000, or contact your local government inspection agency.
WARNING
Incorrectly installed equipment may fail, causing severe injury or property damage.
WARNING
• Do not connect the system to an unregulated city water system or other external source of pressurized water
producing pressures greater than 35 PSI.
• Trapped air in system can cause the lter lid to be blown off, which can result in death, serious personal injury,
or property damage. Be sure all air is out of the system before operating.
WARNING
Produktspecifikationer
| Varumärke: | POLARIS |
| Kategori: | Pomp |
| Modell: | PB4-60 |
Behöver du hjälp?
Om du behöver hjälp med POLARIS PB4-60 ställ en fråga nedan och andra användare kommer att svara dig
Pomp POLARIS Manualer
1 September 2024
31 Augusti 2024
27 Augusti 2024
Pomp Manualer
- Pomp Karcher
- Pomp Nefit
- Pomp Vaillant
- Pomp Al-ko
- Pomp Vetus
- Pomp Bartscher
- Pomp Eurom
- Pomp Generac
- Pomp Ozito
- Pomp Gude
- Pomp Silvercrest
- Pomp Makita
- Pomp Black And Decker
- Pomp Bestway
- Pomp Vonroc
- Pomp Crivit
- Pomp Hyundai
- Pomp Ryobi
- Pomp Sicce
- Pomp Outwell
- Pomp Metabo
- Pomp Worx
- Pomp Milwaukee
- Pomp Sun Joe
- Pomp Tacklife
- Pomp Hazet
- Pomp Einhell
- Pomp Ultimate Speed
- Pomp SKS
- Pomp Gardena
- Pomp Hayward
- Pomp Eheim
- Pomp Nibe
- Pomp Ferroli
- Pomp Husqvarna
- Pomp Melinera
- Pomp Oase
- Pomp Biltema
- Pomp GRE
- Pomp Powerplus
- Pomp Sanibroyeur
- Pomp Danfoss
- Pomp Michelin
- Pomp Scheppach
- Pomp Zodiac
- Pomp Powerfix
- Pomp Topeak
- Pomp Hozelock
- Pomp Bulex
- Pomp Technaxx
- Pomp Lezyne
- Pomp Fluke
- Pomp Blumfeldt
- Pomp For_Q
- Pomp Simpson
- Pomp Zipper
- Pomp Fieldmann
- Pomp WHALE
- Pomp Fluval
- Pomp Fuxtec
- Pomp Astralpool
- Pomp Abac
- Pomp Waldbeck
- Pomp Cannondale
- Pomp Lavorwash
- Pomp Coleman
- Pomp Testo
- Pomp Maruyama
- Pomp Jabsco
- Pomp Toolcraft
- Pomp Eufab
- Pomp Pontec
- Pomp Aerotec
- Pomp Batavia
- Pomp Gardenline
- Pomp Westfalia
- Pomp ESPA
- Pomp Interphone
- Pomp Osram
- Pomp Pedrollo
- Pomp Park Tool
- Pomp Velda
- Pomp Vivaria
- Pomp Plantiflor
- Pomp Verto
- Pomp Little Giant
- Pomp Panduit
- Pomp Wetelux
- Pomp Germania
- Pomp Anova
- Pomp Ubbink
- Pomp DAB
- Pomp Esotec
- Pomp Wayne
- Pomp T.I.P.
- Pomp Rule
- Pomp JANDY
- Pomp Neptun
- Pomp Elpumps
- Pomp Hollex
- Pomp B-Air
- Pomp Baracuda
- Pomp Lifan
- Pomp Enermax
- Pomp Monzana
- Pomp Liberty Pumps
- Pomp BluGarda
- Pomp Alpha Tools
- Pomp Grundfos
- Pomp Madimack
- Pomp Sauermann
- Pomp Eco-Flo
- Pomp Nowax
- Pomp Zoeller
- Pomp Superior Pump
- Pomp SHURflo
- Pomp EvoHeat
- Pomp MSW
- Pomp OKAY
- Pomp FIAP
- Pomp Barwig
- Pomp Ribimex
- Pomp Ebara
- Pomp Perlick
- Pomp Basement Watchdog
- Pomp Ergotools Pattfield
- Pomp Zéfal
- Pomp Zehnder Pumpen
- Pomp Comet
- Pomp SANDPIPER
- Pomp Heissner
- Pomp Blackburn
- Pomp OSIP
- Pomp Franklin Electric
Nyaste Pomp Manualer
1 April 2025
1 April 2025
1 April 2025
1 April 2025
1 April 2025
1 April 2025
1 April 2025
1 April 2025
1 April 2025
1 April 2025