Trek Rail 5 Gen 3 Bruksanvisning

Trek Cykel Rail 5 Gen 3

Läs nedan 📖 manual på svenska för Trek Rail 5 Gen 3 (15 sidor) i kategorin Cykel. Denna guide var användbar för 3 personer och betygsatt med 4.5 stjärnor i genomsnitt av 2 användare

Ladda ner PDF

Sida 1/15

2023 Alloy Rail

5, 7, and 9 Gen 3

SERVICE MANUAL

2023 Alloy Rail

Safety

WARNING

Properly tighten hardware

Always tighten hardware to the specied torque.

Over-tightening hardware could deform or break the

hardware or components. Under-tightening hardware

could cause hardware or components to become loose.

Either situation could damage the bicycle and result in

injury to the rider.

WARNING

Reapply threadlocker

All reused-fasteners with pre-applied threadlocker must

be cleaned with isopropyl alcohol and have new thread-

locker applied before re-assembly. If threadlocker is not

applied, the fasteners may loosen which could damage

the bicycle and result in injury to the rider.

Legend

Apply grease

Do not apply grease

Apply threadlocker

Nm Torque

Hex tool size

Torx tool

Drift size



Zip tie

Contents

52mm

• Boost hub with offset chainring.

Cha inring (1x only)

• 34T

Rear bra ke mount

Minimum Maximum

180mm, direct mount Adaptable to 203mm

Maximu m tire size

Notice: Measurements of actual tires may vary. Always

verify there is sufcient clearance between the tire and

the frame. Improper tire size could damage the bicycle

frame. Trek recommends 6mm clearance above and on

the sides of the tire.

Wheel set Maximum tire size

29" 29" x 2.6"

Water bottle t

Small: Compatible only with the Bontrager Voda 15 bottle.

Requires the cage spacer included with the bike.

Medium: Requires the bottle cage spacer included with

the bike.

Seat post

WARNING

Always follow the seatpost manufacturer’s minimum

insertion recommendation. Failure to follow the recom-

mendation could cause damage to the seatpost and

result in injury to the rider.

Measurement

Maximum insertion Frame

S220mm

M230mm

L260mm

XL 310m m

Seat tube inside diameter 31.6mm

two M6x1.0x25mm bolts

18mmM6x1.0x25

W581379

Fork

Refer to the suspension setup card included with your bike

or the suspension calculator at

Trekbikes.com/suspension-calculator.

WARNING

Exceeding the recommended maximum fork length could

damage the bicycle and result in injury to the rider.

Travel

Axle to Race

Frame size Axle to Race

(mm)

Travel

(mm)

S M ML L XL Recommended 570 160

Safety Rocker pivot and

seatstay and seat

stay

Shock mounts RIB — battery

assembly

Drive unit and

mounting bolts

Specications

0.5°

Headset with Knock

Block

Adjust the geom-

etry

Cable routing RIB — docking

assembly

Battery charge

port cover

Active Braking Pivot

(ABP)

Main pivot and

chainstay and

chainstay

Cable routing Remote Speed sensor

2023 Alloy Rail

Headset with Knock Block

2.5

2Nm

1Upper bearing cover

— 5252157

2Chip bolt — W532763

3Knock Block chip

4Compression ring — W532842

5Upper bearing — W531676

6Lower bearing, 1.5" diameter — W532843

7Crown race, for 1.5" diameter lower bearing —

W532844

Tools

• 2.5mm hex tool

• Grease

Produktspecifikationer

Varumärke:	Trek
Kategori:	Cykel
Modell:	Rail 5 Gen 3
Färg på produkten:	Meerkleurig
Förpackningens vikt:	760 g
Förpackningens bredd:	262 mm
Djuppackning:	382 mm
Förpackningshöjd:	56.5 mm
Rekommenderad ålder (max):	99 jaar
Rekommenderad ålder (min):	8 jaar
Typ av förpackning:	Doos
Ursprungsland:	Tsjechische Republiek
Material:	Kunststof
Föreslaget kön:	Jongen/meisje
Batterier krävs:	Nee
Rekommenderat åldersintervall:	Kinderen
Antal bitar:	603 stuk(s)
Ljudeffekter stöds:	Nee
Montering krävs:	Ja
Batterier-ingår:	Nee
Typ produkt:	Bouwpakket
EU TSD-varning:	Niet voor kinderen jonger dan 18 maanden
VIP-poäng:	487
SALT:	B09BNTQBPG